Maintenance, Caution – Lincoln Electric VANTAGE SVM178-B Manuel d'utilisation
Page 141
MAINTENANCE
D4.5
D4.5
VANTAGE® 500
AIR FILTER
Excessive air filter restriction will result in reduced
engine life.
The air filter element is a dry cartridge type. It can be
cleaned and reused. However, damaged elements
should not be reused. Stop engine after 100 hours of
running time and clean filter element. Replace the filter
if necessary. Service the air cleaner regularly according
to your engine operation manual.
1. Locate the air filter canister located behind the
engine door and mounted to the roof .
2. Remove the air filter element per the instructions on
the Maintenance Instructions located on the door.
(Also in this manual and the Operator’s Manual
3. Remove loose dirt from the element with com-
pressed air or a water hose directed from inside out.
Compressed Air: 100 psi maximum with nozzles at
least one inch away from the ele-
ment.
Water Hose: 40 psi maximum without nozzle.
4. Soak the element in a mild detergent solution for 15
minutes. Do not soak more than 24 hours. Swish
the element around in the solution to help remove
dirt.
5. Rinse elements from inside out with a gentle stream
of water (less than 40 psi) to remove all suds and
dirt.
6. Dry the element before reuse with warm air at less
than 160°F (71°C). Do not use a light bulb to dry the
element.
7. Inspect for holes and tears by looking through the
element toward a bright light. Check for damaged
gaskets or dented metal parts. Do not reuse dam-
aged elements. Protect the element from dust and
damage during drying and storage.
8. Reinstall the air filter element per the Maintenance
Decal.
After six cleanings, replace the air filter. See the
Maintenance Instructions. A cleaned filter will have
approximately 70% of the life of a new filter element.
A restricted filter element may not appear excessively
dirty.
NOTE: If the entire cannister is removed or replaced,
the spring clamps should be tightened to 15-
20 in/lbs. See Figure D4.3
CAUTION
FIGURE D4.3 - AIR CLEANER
Spring Clamps
Torque to
15-20 in/lbs
Latch
Air Cleaner
(mounted
to roof)