Napoleon Fireplaces Vittoria - GD19 - Manuel (Page 2)

2
W415-1004 / B / 08.10.12
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE OF CONTENTS
1.0
INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 GENERAL INSTRUCTIONS 6
2.2 GENERAL INFORMATION 7
2.3 RATING PLATE INFORMATION 7
3.0 VENTING 8
3.1 VENTING LENGTHS AND COMPONENTS 8
3.2 TYPICAL VENT INSTALLATION 9
3.3 SPECIAL VENT INSTALLATIONS 11
3.3.1 PERISCOPE TERMINATION 11
3.3.2 CORNER TERMINATION 11
3.4 VENT TERMINAL CLEARANCES 12
3.5 VENTING APPLICATION FLOW CHART 13
3.6 DEFINITIONS 13
3.7 ELBOW VENT LENGTH VALUES 14
3.8 TOP EXIT HORIZONTAL TERMINATION 14
3.9 REAR EXIT HORIZONTAL TERMINATION 16
3.10 TOP OR REAR EXIT VERTICAL TERMINATION 18
3.11 REAR VENT CONVERSION 21
4.0 INSTALLATION 22
4.1 WALL AND CEILING PROTECTION 22
4.1.1 HORIZONTAL INSTALLATION 23
4.1.2 VERTICAL INSTALLATION 23
4.2 USING FLEXIBLE VENT COMPONENTS 24
4.2.1 HORIZONTAL AIR TERMINAL INSTALLATION 24
4.2.2 VERTICAL AIR TERMINAL INSTALLATION 25
4.2.3 APPLIANCE VENT CONNECTION 26
4.3 USING RIGID VENT COMPONENTS 26
4.3.1 HORIZONTAL AIR TERMINAL INSTALLATION 27
4.3.2 EXTENDED HORIZONTAL AND CORNER AIR TERMINAL INSTALLATION 27
4.3.3 VERTICAL AIR TERMINAL INSTALLATION 28
4.4 VERTICAL THROUGH EXISTING CHIMNEY 29
4.5 MOBILE HOME INSTALLATION 30
4.6 GAS INSTALLATION 31
4.7 OPTIONAL WALL SWITCH 31
5.0 FRAMING 32
5.1 MINIMUM CLEARANCE TO COMBUSTIBLES 33
5.1.1 REAR VENT 34
5.1.2 TOP VENT 34
5.2 MINIMUM CLEARANCE TO COMBUSTIBLE ENCLOSURES 35
5.3 MINIMUM MANTEL CLEARANCES 36
6.0 ELECTRICAL CONNECTION 37
7.0 WIRING DIAGRAM 38
8.0 FINISHING 39
8.1 GLASS DOOR 39
8.2 LOGO PLACEMENT 39
8.3 BURNER INSTALLATION 39
8.4 FACING KIT INSTALLATION/REMOVAL 40
8.4.1 FACING KIT 40
8.4.2 CONTEMPORARY FACING KIT 40
9.0 OPTIONAL BLOWER INSTALLATION 41
10.0 OPERATION 42
10.1 CONTROL FUNCTIONS 43
11.0 ADJUSTMENTS 43
11.1 PILOT INJECTOR AND ORIFICE REPLACEMENT 43
11.2 PRESSURE CHECK 44
11.3 RESTRICTING VERTICAL VENTS 44
12.0 MAINTENANCE 45
12.1 DOOR GLASS REPLACEMENT 46
12.2 CARE OF GLASS 46
12.3 NIGHT LIGHT TM REPLACEMENT 47
12.3.1 BULB REPLACEMENT 47
12.3.2 LENS ASSEMBLY INSTALLATION 47
12.3.3 LENS ASSEMBLY REPLACEMENT 47
13.0 REPLACEMENTS 48
14.0 TROUBLESHOOTING 50
15.0 WARRANTY 52
16.0 SERVICE HISTORY 53