Carter-Hoffmann HP65 - Manuel (Page 3)

Maintenance
Instructions
Trouble/Caution
Light
Replacement
Parts
1. Clean the grease filter daily (see instructions on page one).
2. Clean the cabinet daily (see instructions on page one).
The HP Saute Station is equipped with a trouble/caution light. This light is
located to the right of the On/Off switch. The light will illuminate when the
cabinet is not heating properly. This indicates one or more of the following
conditions:
Air Blockage. The grease filter needs to be cleaned. A clogged grease
filter will block air flow into the cabinet and the cabinet will overheat. The
cabinet is equipped with an automatic shut off when this situation occurs.
Clean the grease filter according to the directions on page 1. If the filter
is too dirty and cannot be cleaned properly, it must be replaced.
If problem is not fixed by cleaning or replacing the grease filter, the
electrical components are damaged (see Electrical Component Failure
below).
Element Failure. If one side of the cabinet is heating and the other isn’t,
an element is not heating properly. DO NOT ATTEMPT TO OPEN THE
HEATING COMPARTMENT AND MAKE REPAIRS. THIS REPAIR
REQUIRES A QUALIFIED SERVICE TECHNICIAN. CALL FOR
SERVICE.
Electrical Component Failure. Moisture may have accumulated in the
heating compartment and may have damaged electrical components.
Component failure may also be caused by failure to clean the grease
filter. DO NOT ATTEMPT TO OPEN THE HEATING COMPARTMENT
AND MAKE REPAIRS. THIS REPAIR REQUIRES A QUALIFIED
SERVICE TECHNICIAN. CALL FOR SERVICE.
120V, 1920 watts, 16 amps, 60HZ, 1PH
Part Number Description
18600-0061 300 o F Auto Reset Hi Limit
18601-1150 Red Pilot Light
18602-0073 On/Off Switch with Circuit Breaker
18602-0099 Quench Arc
18602-0220 Single Thermocouple
18602-0224 Relay
18605-0025 14/3 HJSO Power Cord
18606-0221 NEMA Plug 5-20P
18610-0197 Locknut for Power Cord
18612-0113 Heat Element 900 Watt
18614-0324 Fan Motor
18614-0325 Fan Blade
18616-0249 Controller
18616-9996 Aluminum Cord Grip
Contact factory with your model and
serial number for replacement cart
components.
DO NOT operate
cabinet without
grease filter in
place.
CAUTION
Use only
(OEM) origi-
nal equipment
manufacturer
replacement
parts. Using unauthorized
parts may cause serious injury.
Replacement parts should be
installed by a qualified service
technician.
WARNING