Napoleon Grills GOURMET GRILLS PTSS450RSB - Manuel (Page 2)

2
TABLE OF CONTENTS
General Instructions Page #
Warranty 3
General Information 4
Important Do's and Don'ts 4
Gas Hook-up Instructions 5
Leak Testing Instructions 5
Operating Instructions
Lighting Instructions 6
Cooking Instructions 7
Cleaning Instructions 7
Maintenance Instructions 8
Troubleshooting 9
Ordering Replacement Parts 10
Assembly Instructions Page #
1. Cart Assembly 20
2. Wheel Assembly 20
3. Chassis Assembly 21
4. Grease Tray and Drip Pan Assembly 21
5. Installing Sear Plates, Grills, and Warming Rack 22
6. Bottom Shelf Placement 22
7. Sides and Rear Cart Panel Installation 23
8. Cart Door Installation 24
9. Side Shelf Installation 24
10. Side Burner Assembly 25
11. Propane Cylinder Installation 26
12. Natural Gas Hose Attachment 26
13. Leak Testing Diagram 27
14. Rotisserie Kit Assembly 27
15. Replacement Parts List 28
16. Parts Diagram 30
Do not try to light this appliance without
reading "LIGHTING" instructions section of this manual.
FOR YOUR SAFETY
DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPOURS AND LIQUIDS
IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. AN LP CYLINDER NOT CON-
NECTED FOR USE MUST NOT BE STORED IN THE VICINITY OF THIS OR ANY OTHER
APPLIANCE. IF THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED
EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PER-
SONAL INJURY OR DEATH.
• This gas grill is not intended to be installed in or on recre-
ational vehicles and/or boats.
• This gas grill must only be used outdoors in a well-ventilated
space and must not be used inside a building, garage or any
other enclosed area.
• Keep any electrical supply cord and fuel supply hose away
from any heated surfaces.
• Inspect the fuel supply hose before each use. If there is
evidence of excessive abrasion or wear or the hose is cut, it
must be replaced, prior to using the gas grill, with a replace-
ment hose assembly specified by the manufacturer.
• When the propane cylinder is not disconnected from the
appliance, the gas grill and cylinder must be stored outdoors
in a well ventilated space.
• Do not locate in windy settings. High winds adversely affect
the cooking performance of the gas grill.
• Adults and especially children should be alerted to the
hazards of high surface temperatures. Young children should
be supervised near the gas grill.
• Under no circumstances should this gas grill be modified.
• Gas must be turned off at the propane cylinder or at the
natural gas supply valve when the gas grill is not in use.
• When the gas grill is to be stored indoors, the connection
between the propane cylinder and the gas grill must be
disconnected and the cylinder removed and stored outdoors
in a well ventilated space out of reach of children. Discon-
nected cylinders must not be stored in a building, garage or
any other enclosed area. Natural gas units must be discon-
nected from the supply when being stored indoors.
• The top lid is to be closed during the gas grill preheat period
• Do not use the condiment tray to store lighters, matches or
other flammable materials.
• This gas grill is designed for outdoor use only.
SAFE OPERATING PRACTICES
WARNING
WHAT TO DO IF YOU SMELL GAS:
• Turn off main gas supply.
• Extinguish any open flame.
• Open lid.
• Immediately call your gas supplier, or your fire department if odour continues.