Napoleon Grills PTSS215 - Manuel (Page 3)

3
Do not try to light this appliance without
reading "LIGHTING" instructions section of this manual.
FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VA-
POURS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. AN LP
CYLINDER NOT CONNECTED FOR USE MUST NOT BE STORED IN THE VICINITY OF
THIS OR ANY OTHER APPLIANCE. IF THE INFORMATION IN THESE INSTRUCTIONS IS
NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY
DAMAGE, PERSONAL INJURY OR DEATH.
• This gas grill must only be used outdoors in a well-ventilated
space and must not be used inside a building, garage or any
other enclosed area.
• Keep any electrical supply cord and fuel supply hose away
from any heated surfaces.
• Inspect the fuel supply hose before each use. If there is
evidence of excessive abrasion or wear or the hose is cut, it
must be replaced, prior to using the gas grill, with a replace-
ment hose assembly specified by the manufacturer.
• When the propane cylinder is not disconnected from the
appliance, the gas grill and cylinder must be stored outdoors in
a well ventilated space.
• Do not locate in windy settings. High winds adversely affect
the cooking performance of the gas grill.
• This gas grill is designed for L.P. only.
• Adults and especially children should be alerted to the hazards
of high surface temperatures. Young children should be
supervised near the gas grill.
• Under no circumstances should this gas grill be modified.
• Gas must be turned off at the propane cylinder when the gas
grill is not in use.
• When the gas grill is to be stored indoors, the connection
between the propane cylinder and the gas grill must be
disconnected and the cylinder removed and stored outdoors in
a well ventilated space out of reach of children. Disconnected
cylinders must not be stored in a building, garage or any other
enclosed area.
• The top lid is to be closed during the gas grill preheat period
• This gas grill is designed for outdoor use only.
SAFE OPERATING PRACTICES
WARNING
WHAT TO DO IF YOU SMELL GAS:
• Turn off main gas supply.
• Extinguish any open flame.
• Open lid.
• Immediately call your gas supplier, or your fire department if odour continues.
This gas barbecue is certified under Canadian and American national standards, CSA 1.8 - 2002 and ANSI Z83.11 - 2002 respectively for
outdoor gas grills, with references to ANSI Z21.57 - 2001, CSA 1.16 M79 (r1996), NFPA 302, CFR title 33, ANSI Z21.89 - 2002, ANSI
Z21.72b - 2002, and CSA 11.2b - 2002 and should be installed to conform with local codes. In absence of local codes, install to the current
National Fuel Gas Code CAN/CGA-B149.1 or ANSI Z223.1/NFPA 54, natural gas and propane installation code.
Use only the pressure regulator provided with this barbecue. Replacement pressure regulators must be supplied by or specified by the
manufacturer. The regulator supplies a pressure of 22 inches water column to the gas grill and has a female CGA#600 type fitting. To
install the regulator, screw it into the threaded hole on the right side of the grill. Tube burners may have to be pushed upwards
slightly from underneath to ensure that the orifice is aligned with the opening in the burner. 1 lb disposable cylinders to be used with
this unit must be equipped with a male CGA #600 type connection. This cylinder has a positive seating connection, which will not allow gas
flow until a positive seal has been achieved. To install the cylinder simply screw it into the regulator - tighten hand tight.
OPTIONAL SUPPLY HOSE INSTRUCTIONS: An optional hose is available from your Napoleon Dealer that allows the grill to be connected to
a 20 lb (9.1 kg) cylinder. A dented or rusted cylinder may be hazardous and should be checked by your propane supplier. Never use a
cylinder with a damaged valve. Use only a propane supply cylinder constructed and marked in accordance with the specifications for LP-gas
cylinders of the Canadian Transport Commission (CTC) or the US Department of Transportation (DOT). The propane cylinder must be
provided with a shut-off valve terminating in a propane cylinder valve type QCC1, and a safety relief device having direct communication with
the vapour space of the cylinder. The cylinder supply system must be arranged for vapour withdrawal and the cylinder shall include a collar to
protect the cylinder valve. The cylinder shall incorporate a listed OPD (overfill protection device). To use the hose, connect it (note the
the connection to the 20 lb cylinder is a left hand thread) between the tank valve and the regulator on the grill. These connections
should be tightened hand tight, and leak tested when performing a leak test. Ensure that the cylinder valve is turned off whenever
the grill is not in use.
GENERAL INFORMATION